| 引用本文: | 王辉,杨大伟,刘松霖,王翔宇,宋畅,段炼.O2/CO2条件下煤泥球团的燃烧特性实验研究[J].哈尔滨工业大学学报,2019,51(1):45.DOI:10.11918/j.issn.0367-6234.201711074 |
| WANG Hui,YANG Dawei,LIU Songlin,WANG Xiangyu,SONG Chang,DUAN Lian.Experimental investigation on the combustion characteristics of coal slime pellet in O2/CO2[J].Journal of Harbin Institute of Technology,2019,51(1):45.DOI:10.11918/j.issn.0367-6234.201711074 |
|
| 本文已被：浏览 2303次 下载 919次 |
码上扫一扫！ |
|
|
| O2/CO2条件下煤泥球团的燃烧特性实验研究 |
|
王辉1,杨大伟1,刘松霖1,王翔宇1,宋 畅2,段 炼3
|
|
(1.哈尔滨工业大学 能源科学与工程学院,哈尔滨 150001;2.神华国能集团有限公司, 北京100033; 3.中船重工集团有限公司哈尔滨七○三研究所,哈尔滨 150036)
|
|
| 摘要: |
| 在水平管式炉中O2/CO2条件下对山西吕梁烟煤煤泥进行燃烧实验,研究颗粒直径及氧气体积分数对预干燥煤泥球团燃烧特性的影响. 采用热电偶测量煤泥球团燃烧过程中内部温度的变化,并通过高清摄像机同步记录预干燥煤泥球团的燃烧过程. 在炉温为800 ℃、氧气体积分数分别为10%、20%、30%、40%以及50%的条件下,对6～12 mm范围内4个不同直径的煤泥球团进行燃烧实验研究. 结果表明:不同氧气体积分数下的预干燥煤泥球团呈现出不同的着火方式；煤泥球团内部达到的最高温度随着氧气体积分数的提高而提高,但与煤泥球团直径关系不大；同一粒径下,富氧燃烧条件有助于煤泥的燃尽；煤泥着火延迟时间随氧气体积分数的提高而减少. |
| 关键词: 煤泥 富氧燃烧 内部温度 着火延迟 燃尽时间 |
| DOI：10.11918/j.issn.0367-6234.201711074 |
| 分类号:TQ534 |
| 文献标识码:A |
| 基金项目:国家重大研发计划(2016YFB0600203) |
|
| Experimental investigation on the combustion characteristics of coal slime pellet in O2/CO2 |
|
WANG Hui1,YANG Dawei1,LIU Songlin1,WANG Xiangyu1,SONG Chang2,DUAN Lian3
|
|
（1.School of Energy Science and Engineering, Harbin Institute of Technology, Harbin 150001, China; 2.Shenhua Guoneng Energy Group Corporation Limited, Beijing 100033,China; 3.703 Research Institute of China Shipbuilding Industry Corporation, Harbin 150036, China）
|
| Abstract: |
| To understand combustion characteristics of Lvliang bituminous coal slime from Shanxi Province and to study the effects of changing particle diameter and oxygen volume fraction, O2/CO2 combustion experiments of coal slime pellets were carried out, in which the thermocouple was used to online measure the inner temperature during the combustion process, and simultaneously the whole combustion process was monitored by a high-resolution camera. The results indicate that the dry coal slime pellets show different ignition modes at 800 ℃ under different conditions of 10%～50% O2 concentrations. The maximum inner temperature of the coal slime pellets increases with the increasing of volume fraction, but irrelated with its diameter. The enrichment of oxygen facilitates burnout of the coal slime pellets with same particle sizes. The ignition delay time decreases as the volume fraction increases. |
| Key words: coal slime oxy-fuel combustion inner temperature combustion delay burnout time |
